|
|
|
#1
12-12-2015, 03:59 PM
|
|||
|
|||
Baja 150
I am new to the site. I discovered site when someone gave me a Baja 150 that had been sitting for a couple of years. Cleaned Carb but couldn't get spark. Your threads helped me diagnose issue (lines from magneto was reversed to the CDI) and got kart to run. I have a couple issues and need some help.
1) Engine will only start if I use a little starter fluid. So I am wondering if that is the carb and I need to clean again? 2) I ran the kart the other day and getting some oil (smells like some gas in it) that comes into air filter box. Also when it runs, it feels like the engine never really runs to full throttle and is missing a little. So is this a fuel issue? |
|
#2
12-13-2015, 07:54 PM
|
|||
|
|||
|
Is the spark plug old? Also check your valve clearances cause my buggy was super hard to start and I set them both to .005 and now it cranks in 1 turn over.
__________________
2014 Trailmaster 150, Dr pully variator, gtc clutch, cai, orange coil, 20" lightbar, 6"pods, 61mm BBK,yellow clutch spring, glasspack exhaust...to be continued |
|
#3
12-13-2015, 08:22 PM
|
|||
|
|||
|
Spark plug is new. I'll check clearance. Would that cause the blow-by as well?
|
|
#5
12-15-2015, 05:23 AM
|
|||
|
|||
|
Oil in the air filter box.
I pulled off carb again and took apart the auto choke and it was fairly dirty. Hopefully that is the cause for not starting. I am going to check clearances tonight. |
|
#6
12-21-2015, 08:02 PM
|
|||
|
|||
|
So I checked clearance and cleaned out auto choke. Go kart starts well but doesn't run well at full throttle. Starts to putter out under a load (i.e. on a hill) or as you accelarate. Almost seems like it isn't getting enough fuel. Only vacuum hose from carb looks ok. Any ideas other than replacing carb?
|
|
#7
12-22-2015, 08:30 AM
|
||||
|
||||
Take the top off of your carb , take out diaphragm and slide , inspect .
Here's the fix . Remove needle from slide , find some very tiny washers , try three at first and place under head of needle to raise it in it's seat . Might need only two or one . Results in more fuel earlier at higher RPM . I have done this to three carbs with great results . AND YES THEY WERE 100% CLEAN , INCLUDING EMULSION TUBE . 
__________________
2011 BMS KING COBRA 150 Sold YERF DOG SPIDERBOX's Sold YERF DOG 3203's. Sold MANCO SILVER FOX. Sold 2009 POLARIS 500 HO SPORTSMAN 4X4 2002 POLARIS 500 HO SPORTSMAN 4X4 2000 POLARIS MAGNUM 2X4 HALF A DOZEN CHEVY 4X4's NEED-MO-BUGGY
|
|
#8
12-28-2015, 11:07 PM
|
||||
|
||||
|
After checking all the above mentioned if nothing, check inside your cvt. Look at your weights!!! Also replace your fuel filter, and spark plug cable. Get the orange one.
__________________
2. 150cc carters. 1. Baja reaction 150cc dr2 variators Jerseydevil hp. Pipes unifilters gates belts. Yellow main springs hd. Orange coils. |
|
#10
07-11-2016, 11:48 PM
|
|||
|
|||
|
I just fixed this same bogging down under full throttle issue by putting in a smaller jet in the carb. Took it for a spin tonight and it runs a lot better. Check your spark plug, if it's black and oily then it's running too rich. But don't go too lean or you'll burn up your engine.
|
|
#11
07-12-2016, 12:25 AM
|
|||
|
|||
|
Sorry I missed this whole conversation (new guy myself), but for anybody else that stumbles upon this:
Those teeny tiny washers that Oldkid referred to can be found at Radio Shack. They come in a plastic bag with 4-5 different sizes for a couple bucks. |
|
#12
07-12-2016, 03:10 PM
|
||||
|
||||
|
the carbs for these buggies are pretty inexpensive. around 20 bucks online. I don tknow if I would pull my hair out clening one several times rather than just swapping it out for a new one. I would replace the fuel lines and pull the tank and make sure its clean and debrise free. maybe even throw in a new fuel pump vacuum switch or whatever you want to call it which is maybe 10 bucks.
|
|
|
