BuggyMasters.Com - An On Line Mini Buggy Forum and Go Kart Forum

Go Back   BuggyMasters.Com - An On Line Mini Buggy Forum and Go Kart Forum > Technical Discussions > 150cc GY6 and Under Engine Tech

150cc GY6 and Under Engine Tech GY6 and Smaller Technical Discussion Forum

Reply
 
Thread Tools
  #1  
Old 07-09-2012, 08:31 PM
McMongo McMongo is offline
Lurker
 

Join Date: Jul 2012
Posts: 5
Default Roketa 110cc GK-17 Charging Problem

I'm new here so bear with me, did a search and didn't find what I was looking for.

Just picked up a Roketa 110cc for the kiddos, it's not charging the battery, I checked the Yellow and the White wire at the voltage regulator and got no voltage, did the same on the Engine side of the connector comming out of the stator and nothing there either, the ground is good at the stator. I'm not shure what to check or what to do next, what parts I might need, Ect. Any advice would be highly appriciated.

Thank you,
David H.
Reply With Quote
  #2  
Old 07-10-2012, 09:33 AM
SYCARMS's Avatar
SYCARMS SYCARMS is offline
Supporting Vendor
 

Join Date: Sep 2009
Location: Senatobia, Mississippi
Posts: 3,375
Default

If you have no power from the stator it is most likely a bad stator or a broken wire inside. You will need a stator or I have seen the flywheel magnet go bad. You will need to pull it off and inspect. When you pull the stator( it removes with the cover) you should feel the magnet pull, if not the flywheel is bad. Use your ohm meter to check for opens in the stator. You will need to post some pics of the stator and regulator since they used one of about 3 type stator / regulators on the 110cc engine.
Reply With Quote
  #3  
Old 07-10-2012, 02:51 PM
McMongo McMongo is offline
Lurker
 

Join Date: Jul 2012
Posts: 5
Default

Any tips where or what wires to ohm out?
Reply With Quote
  #4  
Old 07-10-2012, 10:02 PM
SYCARMS's Avatar
SYCARMS SYCARMS is offline
Supporting Vendor
 

Join Date: Sep 2009
Location: Senatobia, Mississippi
Posts: 3,375
Default

If you can send me a pic of the stator you have I can get the actual specs from the Honda manual. You can PM pics to me or send them to tom@sycpowersports.com
Reply With Quote
  #5  
Old 07-11-2012, 07:32 AM
McMongo McMongo is offline
Lurker
 

Join Date: Jul 2012
Posts: 5
Default

will do Prob this week end when i have some time to mess with it.
Reply With Quote
Reply

Thread Tools

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump


All times are GMT -5. The time now is 06:23 PM.


Powered by vBulletin® Version 3.8.3
Copyright ©2000 - 2024, Jelsoft Enterprises Ltd.